For sale here is a complete Automatic Soft-Cloth Car Wash. Most of the equipment was install in 1987, at a cost of about $100,000.00 (Not including the conveyor system, and the building). I believe the conveyor equipment was installed in 1974 (Quite old, but still works fine). This equipment is fully operational and Runs well. The Sherman Equipment is very High Quality (constructed of Heavy Gage Stainless Steel, and good quality components). The conveyor is a FlaPan Model 1084 (Log-Chain type, Above Floor, Surface mount).

The Control System was upgraded in 2001 and again in 2010. Includes a late model Koyo DL-6 PLC (Ladder Logic programmable), Software and Full Documentation. I can provide documentation for all Wiring, Plumbing Connections, Software, Etc.

Equipment includes:

1. Sherman (Hanna) Soft-Cloth Car-Wash System.

Which Includes:

A.

One Side-to-Side Mitter Machine (Scrubs the top of a car with long vertical cloth strips, that swing side-to-side).

B.

Left and Right side Van-Washers (Vertical Rotating Brush Machines, that scrub the sides of a car).

C.

Two pair Chemical Foamers. One for Soap, and one for Foaming Clear-Coat Protectant.

D.

Tire-Cleaner Applicator Machine.

E.

Left and Right side Tire Scrubbing Machines.

F.

One Front-to-Back Mitter Machine (Scrubs the top of a car with long vertical cloth strips, that swing Front-to-Back).

G.

Stainless Steel Spray Arch for Wax, and Rinse Agent.

H.

60 HP Blow-Dryer Machine, with pneumatic Overhead Boom, and Side Strippers.

I.

Complete Programmable Control System (includes PLC, Motor Control Center, Operator Stations, Sensors, Switches, Valves, and all
associated Wiring).

J.

Complete Chemical Mixing Stations, with Stands and all related equipment.

K.

Self-Service Tunnel System. Consisting of four instructional light-box signs, one Customer Interface Box, and Traffic Signals.

M

Many Spare Parts.

2. Hydraulic Conveyor System.

A.

15 HP Sherman Hydraulic "Power-Pack" unit.

B.

Sherman Correlator (Sliding Plate System, that helps align cars to the conveyor).

C.

FlaPan Model 1084 Conveyor.

D.

All related hardware.

E.

Spare Parts.

3. Air Compressor

This is a late model 5 Hp Ingersall Rand Two-Stage, with a 460Volt 3-Phase Motor.
Very Nice Unit.

4. Large Tank-Type Water Heater

80 Gal, 200,000 BTU, A.O Smith (Very High Capacity, for Tunnel equipment).

5. Small Tankless Water Heater

Bosch Power-Star Model AE-12 (to supply Self-Serve Power Wash and Bathroom faucet).

6. Self-Serve Power Wash system

With coin operated GinSan Controls and 5 HP Cat-Pump.

7. Doyle Coin-Vac

8. Ceiling Fans

9. 24 hour Surveillance System, with Night Vision.

Picture Gallery: